[Author Index]
[Date Index]
[Thread Index]
[Date Prev][Date Next][Thread Prev][Thread Next]
Re: [ST] coolant flush, 2000 Sprint ST
- Subject: Re: [ST] coolant flush, 2000 Sprint ST
- From: triumph1@xxxxxxxxxxxxx
- Date: Sat, 22 May 2004 18:20:15 -0500
Would assume it is the same as an 00 RS. Just did mine last month. You
will have to remove the left side fairing. There is a bleed nut on top
of the thermostat housing which is just to the right of the coolant
cap. 10mm socket, loosen the bleed nut. There is a nut on the left
side on the head of the motor which is the drain plug. this is located
just above the water pump housing. Remove the plug after the bleed
screw is loose and have something to catch the old coolant in. Let it
drain completely, replace plug, fill with new coolant 50/50 mix
distilled water/dexcool or straight dexcool. I run straight dexcool. I
believe the 50/50 mix is an EPA thing. Fill through the cap opening
just to the left or front of the bike until coolant can be seen where
the bleed screw is, this is to ensure all air is out of the system. I
had air in mine and the bike ran hot , very hot until the level went
down and I could add more. My bleed screw was/is stripped from the
factory and cannot be removed. So just run the bike until no coolant
can be added, put cap on , tighten bleed nut and add more in the
overflow resevor if needed. If it runs hot don't panic it is air in the
system somewhere and it should work it's way out. Just don't let the
temp rise above 230 degrees F. Remember though that if it runs hot,
after you shut the bike down it will rise in temp. You should not have
this problem if your bleed nut is removable.
Tim Elliott
Kyle Clarke wrote:
>Does anyone have / could anyone give a quick rundown of steps to
>flush/replace coolant in a 2000 Sprint ST?
>
>Ordered factory service manual today, but won't get for awhile.
>
>Thanks. Kyle.
>
>
>
> * * * * * * * * * * * * * * * * * * *
> The ST/RS Mailing list is sponsored by Jack Lilley Ltd.
> http://www.TriumphNet.com/st/lilley for more info
> http://www.TriumphNet.com/st for ST, RS and Mailing List info
>
>
>
>
* * * * * * * * * * * * * * * * * * *
The ST/RS Mailing list is sponsored by Jack Lilley Ltd.
http://www.TriumphNet.com/st/lilley for more info
http://www.TriumphNet.com/st for ST, RS and Mailing List info
=-=-=-= Next Message =-=-=-=-=-=-=-=-=-=-=-=-=-=-=-=-=